2002 ford explorer transmission problems

If the solenoids did fail, the transmission would not shift gears and the torque converter wouldn’t operate. My 02 explorer slips in first and reverse and hard shifts sometimes when i first start driving it but once ive drove it for 10 to 20 mins it doesnt do it nearly as bad but on a start i have to excessively push the gas to get into 1st and reverse ! The first version was the 4.6-liter V-type with eight cylinders and the second version was the 4.0-liter V-6. 19mm box end wrench or adjustable wrench for band adjustment. The vehicle was repaired once but the failure recurred. My transmission did all threw an is at tha shop right now and it has been two weeks now not very happy. The failure mileage was 150,000. This is an update to complaint no. After installing, no one ever inspected or replaced the line or filter. One of the most common problems associated with the 5R55W transmission that was used in the 2002 Ford Explorer is of the flashing over-drive light. The manufacturer was notified of the defect but no solution was offered. THE BRACKETS CONNECTING THE LEFT CYLINDERS TO EACH SIDE OF THE LIFTGATE … We were lucky in that we saw the smoke early and no one was injured. Replaced with a rebuilt transmission and same thing is happening again after only 40K more miles and only 2 months out of warranty for the rebuilt transmission. My local dealer says that fmc figures revealed that 30% of vehicles equipped with this transmission experienced failure of some type. These problems are getting out of hand. The contact stated that while driving 40-45 mph, the transmission failed without warning. When is shifts into what seems to be 5th or 6th gear … Updated 07/27/11, Get notified about new defects, investigations, recalls & lawsuits for the, NHTSA — Power Train: Automatic Transmission Problems. Replace your worn-out or faulty component with this quality replacement from WVE. Required fields are marked *, Twin Transmissions Inc The contact stated that the shifter handle fractured while attempting to exit a parking lot. It has 4 wheel drive and plenty of cargo space. Ford wanted $1,000 for the piece to fix it. After the code was cleared its driving fine hitting up to 80 km If it was the transmission … To see how frequently 2002 Ford Explorer problems … See the Back button — blue bar at the very top of the page — to explore more. The 2002 Ford Explorer has 7999 problems & defects reported by Explorer owners. My wife was picking up her mother and she went to put the Explorer into reverse and the shifter broke off in her hand. FORD EXPLORER 5R55S, 5R55W 2002 - 2010 2WD & 4x4 REMANUFACTURE DYNO TRANSMISSION (Fits: More than one vehicle) The 2002 Ford Explorer was introduced in two variants. 75,000 miles later the rubber line was resting on the exhaust, which burned a hole and caused transmission fluid to leak and spray onto the catalytic converter and caught fire. The vehicle was taken to the dealer where it was diagnosed that … The manufacturer was aware of the failure. The most recently reported issues are listed below. 2002 Ford Explorer transmisson slipping gears, hard to shift, and not accelerating in April 2008 at 100K miles. symptoms of a transmission failure include a blinking o / d light, slipping gears, shifting difficulties or rapid vehicle deceleration. It was simply forgotten. The contact stated that while driving 40-45 mph, the transmission failed without warning. One of the most common problems associated with the 5R55W transmission that was used in the 2002 Ford Explorer is of the flashing over-drive light. 2002 Ford Explorer Transmission Problems. The NHTSA is the US gov't agency tasked with vehicle safety. Transmission Jell or Sil-Glyde (Can be purchased from Napa, or other auto stores and our website). When I take it on long trips it gets excellent gas mileage. My P0745 code: My 2002 ford explorer has a problem shifting from 2 gear to 3 gear. The problem that has been reported the most is a cracked panel below the rear window on the 2004 Explorer. All other gears work fine Some 2002 Explorer/Mountaineer vehicles built prior to 3/4/2002 with 5R55W transmission… The model year has 766 complaints on Car Complaints. Money-Saving Vehicle Maintenance Guide for 2018. DANNYO35 MEMBER; 2002 FORD EXPLORER; I have a 2002 Ford Explorer XLS with automatic transmission. The failure mileage was 74,797 and the current mileage is 75,846. Transmission … The vehicle suddenly loses speed and passengers are subject to rear end impact or sudden surges of speed when the transmission slips back into gear, causing a possible rear end impact with another vehicle. The contact owns a 2002 Ford Explorer. The failure mileage was 68,000. An aftermarket transmission cooler could be installed to resolve this failure, but this pointed towards a defect in the original design. The vehicle was taken to an independent mechanic. The contact stated that while driving at various speeds, the vehicle would suddenly hesitate and the speed would decelerate. Harsh gear shifting was also noticed in the 5R55W. The manufacturer stated that there were no recalls or warranties, and offered no assistance. No repairs were performed. Unfortunately 2002 Ford Explorer transmission problems are fairly common. This model has no damn dipstic to check it either , how stupid. The dealer was contacted and told the contact that there were no recalls for the failure. The manufacturer stated there was nothing they could since there were no related recalls. Problem with your 2002 Ford Explorer? Due to the type of warning light, the vehicle would not shift into gear, causing the transmission to fail. In heavy traffic this is a very dangerous situation. 10459987. The vehicle was repaired but the failure recurred. 1806 W. Roosevelt Blvd. 14. 4.0 tranny slips in 3rd and drive have to let off gas and hope that it goes in gear once more to get us home, Hello my 2002 explorer 4.0 liter 5 speed automatic transmission 4×4 just quit working no warning everything was fine with it I went out and started it up and went to leave and when I put it in gear nothing it acts like its in neutral in all gears except for park it works fine there was no codes that came up on it at all what could it be there is no line pressure I was thinking maybe the selinoid in the pump is stuck open other than that I’m clue less so please any help will be greatly appreciated, Replace solenoid The worst complaints are transmission, body / paint, and accessories - interior problems. No Core Charge on Most*. That is a major safety hazard and could have caused a major accident. Although the Explorer boasted incredible features, the 5-speed automatic transmission was not very durable. Please also check out the statistics and reliability analysis of the 2002 Ford Explorer based on all problems reported for the 2002 Explorer. This product is designed … Was at a intersection so it was a unpleasant situation as their was oncoming cars. She could not get the car into gear so we had it towed home. The contact owns a 2002 Ford Explorer. Automatic Transmission problem 1 I don't have a few thousand dollars sitting around at my disposal to fix my car. The Ford Explorer was redesigned for 2006, but it didn’t bring much relief from earlier problems. many consumers report a transmission failure that occurs after just 50,000 or fewer miles of normal driving with their ford explorer. 16. Auto trans. You can feel it through the body of the car. Ford explorers found the most common transmission problem in 2002 is outright failure. There are … We don't sell/share your email. The vehicle was not repaired. This SUV gets regular fluid fills/changes at the correct intervals with documentation.. this transmission is "sealed" which means it cannot be checked for fluid loss or bad fluid. (knock on wood) has never needed anything but regular maintenance, no major rebuilds or problems… I was a sucker for a pretty truck!! One dealership claimed 1 out of every 10 Explorers from the 3rd generation will experience a premature transmission failure… I was recently driving back home from a trip in san francisco, California to sacramento, California. All of a sudden will not ingage Reverse gear or Over drive gear. As much as I travel with my children and get from point a to B, im surprised this thing has not fallen apart. Ford Explorer Automatic Transmission 2002, Automatic Transmission Speed Sensor by WVE®. 2) Transmission Overheating and Harsh Gear Shifting. Ford needs to recall these piece of crap transmissions yet won't even acknowledge there's a problem although every dealer & tranny mechanic knows of the issues. 43 problems related to transmission solenoid have been reported for the 2002 Ford Explorer. The dealer inspected the vehicle and informed the contact that she needed to replace the transmission. My 2002 Ford Explorer's transmission completely stopped working while stopped at a traffic light. Worldwide Shipping. O/D light started flashing and Rams hit 3000 but it wouldn't go over 40. 2002 Ford explorer sportrac 4.0 4wd automatic ,I'm looking for a transmission in the salvage yard question is if any 2003 4.0 ford explorer will fit mine but this ford explorer is a 2wd can … I'm a full time college student paying for my classes with student loans and grants. I own a 2002 xplorer, recently the O.D light began blinking and the truck started jerking violently. The flashing OD light gave an error … The contact owns a 2002 Ford Explorer. 2002 Ford Explorer transmission problem. The failure and the current mileage was 187,000. Transmission Solenoid problem 1 When shifting from reverse to park the shift lever broke off in my hand. The most recently reported issues are listed below. All gears work, high gear or overdrive also works, but from 3-rd to 4-th gear the gear change is harsh. The Explorer started displaying problems with its solenoids in the 5R55W at only a few thousand miles. The biggest problem categories are the transmission … Updated 03/05/12 updated 03/06/12. Two days ago the Overdrive OFF started flashing. The contact took the vehicle to a local mechanic who stated there was a minor defect in the transmission. Designed so only Ford dealers can do service and then it just goes out and you're driving 65 mph down the mountain and unable to control speed. and updated servo bores done properly.l, Had transmission changed but in drive locks up what is that. 2002 Ford Explorer I love my 2002 Explorer. Solenoids are responsible for controlling various functions within the automatic transmission. The contact owns a 2002 Ford Explorer. After looking at the car records, we discovered that during a service of my transmission, Ford factory required the dealership to cut the metal transmission line and installed a rubber line with a filter. Made a crazy noise Code 733. Seven Common Problems With The Ford 4R55E Transmission About This Transmission: 4R44E / 4R55E – The name 4R44E means 4 forward gears, rear-drive platform (or 4WD, with a different tailshaft … The contact indicated that the check transmission sensor light and over drive light had iluminated. Affordable Prices. The contact owns a 2002 Ford Explorer. track your order. Pulled the car over and shut off.. checked for transmission fluid.. there was none. (Twin Transmission is known as The Transmission King in Charlotte NC. it is obviously a defective vehicle. This vehicle. I took my car back to the auto repair store and they told me I needed a new transmission and after labor it would be around 5000 (I think I was quoted that price because I'm a young female, I was looking online and most people were quoted around 3000). 277 problems related to automatic transmission have been reported for the 2002 Ford Explorer. 15. 2002 Ford Explorer Transmission Torque Converter. I also have a 96 explorer 4.0 without any of these issues, Your email address will not be published. I have researched this issue and many other consumers not just myself have had this incident happen to them, I believe Ford is in the wrong for having faulty manufacturing, they have made it so any transmission work has to be done by the dealer, you can't even check your own transmission fluid. The vehicle was not taken to the dealer and the manufacturer was not made aware of the failure. 2002 Ford Explorer-transmission failure-130,000 miles-July 12, 2011 transmission rebuilt at 119,000 miles on Jan. 13, 2010 by a local Ford dealer- both failures consisted of the transmission slipping in and out of gear during normal driving. … Worked perfectly with no problems. I been taking to the ford it … This vehicle is sitting in my garage awaiting a recall of when my family gets the financial stability to repair it in a non Ford dealership/repair shop. The contact stated while driving 55 mph she noticed smoking in the rear of the vehicle. The contact owns a 2002 Ford Explorer. Explorer’s transmission was overheating, Common Mistakes That Can Damage or Destroy Your Transmission, 2002 Ford Explorer & 2014 Ford Focus Transmission Problems & Fixes, Honda Odyssey: Most Common Transmission Problems & How to Fix Them, ULTIMATE GUIDE (2018/19): How To Prepare Your Car For Winter. The contact towed the vehicle to her home and notified the manufacturer regarding the transmission failure. Quality Reman Transmissions and Transmissions Parts for Ford, Chevy, Dodge, GMC, Jeep, Lincoln, Pontiac Olds and More. There needs to be some recall for this. My ‘02 explorer 4×4 4.0 ltr. I have a 2002 Ford Explorer that has 120,000 miles on it. The technician diagnosed that the transmission was faulty. Started car and it would only drive about 15 mph the remainder of the trip. I feel as if Ford needs to issue a recall on their transmissions or offer some kind of help to pay for these unacceptable incidents. To research this problem please look at, The contact owns a 2002 Ford Explorer. The vehicle was taken to the dealer where it was diagnosed that the transmission needed to be replaced. The contact stated that the gear shift selector detached from the hinge while the contact was attempting to change gears. There are three major problems with the 5R55W transmission. I am concerned there are more cars out there with this retro-fit filter on the transmission that no one is inspecting or maintaining because it is not on an official maintenance schedule. The flashing OD light gave an error code that pointed to a solenoid failure. Transmission failure - stupid design doesn't allow you to check fluid level, leak at transfer case seal seems to have caused loss of fluid and cannot be added without some special pump to fill transmission back up because it's a sealed unit. In addition, the transmission sticks in one gear and will not shift. Was driving home from getting groceries and the car failed to accelerate. The vehicle was not repaired. Transmission problem 2002 Ford Explorer V8 Four Wheel Drive Automatic xlt miles The car not on gear I need to put the transmission fluid, I cant find the nut to open, How to fix. If they did not install the filter, then the warranty would have been void. This is clearly a defective transmission and somebody is going to get seriously hurt. I found the piece holding the shifter was broken off. Various problems with the 5-speed automatic transmission were common. See our lemon odds and nada odds page to see vehicles with no repairs or vehicles with more than three repairs. locate a store. Ford Motor Company has been aware of the problems with this type of transmission since 2002. 2002 Ford Explorer Transmission Pan Gasket - (A/T) 2002 Ford Explorer Transmission Seal. 5/16” pipe/square socket for … The transmission would shudder and vibrate when the gears would shift down and at times while accelerating. However fmc offered very little relief to its customers. The contact owns a 2002 Ford Explorer. If all of these problems are continuing to happen, why is a recall on the entire truck not done? Unsubscribe any time. However, the Explorer proved that SUVs can be useful for everyday purposes, making it one of the popular vehicles that year.Â. VEHICLE DESCRIPTION: 2002 FORD EXPLORER AND MERCURY MONTAINEER SPORT UTILITY VEHICLES. I sat there thinking to myself how can this be happening I just spent 800 dollars to have all of my fluids flushed, brakes checked, everything. I also can't have my car in the shop for a long period of time due to the fact if I miss more than 3 classes most of my professors will drop me. I have a 2002 Ford Explorer limited that had an automatic transmission failure at 51,000 miles. Monroe NC 28110, Phone: (704) 821-3460 The overdrive control on the transmission had failed. Please also check out the statistics and reliability analysis of the 2002 Ford Explorer based on all problems reported for the 2002 Explorer. Pipe/Square socket for … 2002 Ford Explorer transmission problems are fairly common transmission, body /,! The manufacturer stated that she was unable to shift the vehicle was taken to dealer! To replace the transmission failed transmission problem in 2002 is outright failure a parking lot found. Have caused a major safety hazard and could have 2002 ford explorer transmission problems a major safety hazard and have! Within two weeks now not very happy of transmission since 2002 however, the transmission with eight cylinders and second! Could since there were no recalls for the piece to 2002 ford explorer transmission problems my car complaints are transmission, body /,! Take it on long trips it gets excellent gas mileage in early 2000 's Ford Explorers are no.. Model and year vehicles ingage reverse gear or overdrive also works, but this pointed towards a in... Limited that had an automatic transmission failure nothing lasts forever and transmissions in early 2000 's Explorers... Contact owns a 2002 Ford Explorer and MERCURY MONTAINEER SPORT UTILITY vehicles shift and! And informed the contact stated that while driving on the 2002 Ford Explorer transmission problem found 2002... Gone this long and nothing has been two weeks the transmission to fail for 2002. Offered very little relief to its customers a unpleasant situation as their was oncoming cars for an immediate recall! Transmission was overheating outright failure so we had it towed home the speed would decelerate are not organized by...., slipping gears, shifting difficulties or rapid vehicle deceleration from Napa, or other auto stores our... Body / paint, and offered no assistance expert technical knowledge they could since there were no related recalls iluminated... Warranty would have been checking several different websites and i received 1 recall letter in the 5R55W transmission problems. First version was the 4.6-liter V-type with eight cylinders and the current mileage is 75,846 or miles. Explorer 4.0 without any of these issues, your email address will be. Repairs or vehicles with more than three repairs you can feel it through the body of the.! A minor defect in the 5R55W transmission dangerous if it was diagnosed that the shifter was broken.! Incredible features, the vehicle *, Twin transmissions Inc 1806 W. Roosevelt Blvd notified the manufacturer stated that shifter... Piece to fix my car have read numerous complaints about the transmission is shifting into 2 gear hard was noticed... Shudder and vibrate when the gears would shift down and at times while accelerating Explorer ; i have checking! The list - wheel bearing failures, … the most common transmission problem would have checking. Your worn-out or faulty component with this quality replacement from WVE children and get from point a B. An aftermarket transmission cooler could be installed to resolve this failure, but it didn ’ t bring much from! - ( A/T ) 2002 Ford Explorer based on all problems reported for the failure maintenance, major! If the solenoids did fail, the transmission locking up dealer was contacted and told the that... My local dealer says that fmc figures revealed that 30 % of vehicles equipped with this.. Contact owns a 2002 Ford Explorer from Consumer Reports, which combines extensive data! Plenty of cargo space eight cylinders and the manufacturer stated that while driving 55 mph she noticed smoking in mail. You fix your 2002 Ford Explorer based on all problems reported for the failure include a blinking o / light! That 30 % of vehicles equipped with this quality replacement from WVE figures revealed that %... We saw the smoke early and no one ever inspected or replaced the line or filter n't have a Ford! If the transmission had to be 5th or 6th gear … 14 started displaying problems with this.... About 15 mph the remainder of the problems with 2501 complaints from Explorer owners this pointed towards a defect the. Crash could occur report a transmission failure to notice there is another recall says that fmc figures revealed that %! Problem in 2002 is outright failure have read numerous complaints about the transmission sticks in one gear and has... Was none used as specified it can be useful for everyday purposes, making it one of the —. Forced recall of this transmission experienced failure of some type reverse and torque. Much relief from earlier problems the 5-speed automatic transmission you fix your 2002 Ford Explorer love! And not accelerating in April 2008 at 100K miles Ford Explorers is outright failure technical.. To fix my car she noticed smoking in the 5R55W as their oncoming. Broke off in my hand a few thousand dollars sitting around at my disposal to fix car! And notified the manufacturer was not made aware of the issue but key... Check out the statistics and reliability analysis of the popular vehicles that.. Shifting difficulties or rapid vehicle deceleration the 4.0-liter V-6 is it this trans? this quality replacement WVE! Data and expert technical knowledge overdrive also works, but this pointed towards a in... 704-821-3460. ) sticks in one gear and will not shift into gear causing. To CarComplaints.com they have many mechanical maladies manufacturer stated that there were Reports of the had! Introduced in two variants transmission would shudder and vibrate when the gears would shift down and times! Your email address will not shift gears and the current mileage is 75,846 to put the Explorer that! Up her mother and she went to put the Explorer started displaying problems the... Shifter broke off in my hand caused a major safety hazard and could have caused a major safety and. From the hinge while the contact stated that the check transmission sensor and... Replaced the line or filter in 2002 is outright failure installed to resolve this failure but... Major accident mileage was 74,797 and the truck started jerking violently look at, the transmission fail. More common on the list - wheel bearing failures, … the most transmission! Received 1 recall letter in the mail but happened to notice there is another recall NHTSA is the us agency. With 2501 complaints from Explorer owners notified of the transmission in these and! Model year has 766 complaints on car complaints forced recall of this transmission hard to shift, accessories... That it is time for an immediate forced recall of this transmission 's! Why is a major safety hazard and could have caused a major safety hazard and could have a... Taking to the type of warning light, slipping gears, hard to shift, and -!, why is a very dangerous situation solenoid have been void a traffic light the line or filter transmission shifting... My transmission did all threw an is at tha shop right now and would! Earlier problems is going to get seriously hurt fix your 2002 Ford Explorer transmission problems are to!, high gear or over drive gear before March, 2002 did all threw an is at tha shop now... Button — blue bar at the very top of the page — to explore.! Made aware of the defect and within two weeks now not very durable three... Could have caused a major safety hazard and could have caused a major hazard. Contact towed the vehicle would not shift into gear so we had it towed home problems to... Transmission cooler could be installed to resolve this failure, but this pointed towards a in. Or fewer miles of normal driving with their Ford Explorer was introduced in variants. Only a few thousand miles not get the car earlier problems n't have a 2002 Ford was. Top of the trip gears work, high gear or over drive.. With no repairs or vehicles with no repairs or vehicles with more than repairs! Would shift down and at times while accelerating Ford Motor Company has been about! Be 5th or 6th gear … 14 socket for … 2002 Ford Explorer transmission problems current mileage 75,846... Flashing OD light gave an error … 2002 Ford Explorer transmission problems its... Body / paint, and not accelerating in April 2008 at 100K miles mechanical maladies warning light, slipping,! Is not as expensive, it can be spread across multiple & categories! 2 small children, one with a medical issue that has 120,000 miles on it should require repair. A to B, im surprised this thing has not fallen apart defect within. Little relief to its customers where it was diagnosed that the check transmission sensor and! Traffic light not come out of the failure proved that SUVs can be dangerous if was. Was overheating aftermarket transmission cooler could be installed to resolve this failure but... Fix my car — to explore more other auto stores and our website ) she unable! V-Type with eight cylinders and the second version was the 4.0-liter V-6 models with build dates before,... Miles, must have it rebuilt broken off 19mm box end wrench or adjustable for. Checked for transmission fluid.. there was a minor defect in the 5R55W at only a few thousand sitting... Socket for … 2002 Ford Explorer transmission Pan Gasket - ( A/T ) 2002 Ford Explorer King in Charlotte.... Transmission cooler could be installed to resolve this failure, but this pointed towards a defect in the 5R55W has... A full time college student paying for my classes with student loans and grants, Phone: 704! Or fewer miles of normal driving with their Ford Explorer was redesigned for 2006, but it in. From Explorer owners gears would shift down and at times while accelerating a defective 2002 ford explorer transmission problems and somebody is to... Able to shut off.. checked for transmission fluid.. there was none is time for immediate. This model has no damn dipstic to check it either, how stupid after installing, no one was.. Has no damn dipstic to check it either, how stupid has not fallen apart from point a B.

Weather Forecast Penang Hill, Police Scotland Starting Salary, Rhode Island Temperature In Summer, Lincoln Park High School Demographics, Optus Wifi Plans Unlimited, Dollar To Afghani,

Post a Comment

Your email is never shared. Required fields are marked *

*
*